Spicy Corn and Bacon Macaroni and Cheese

Share this post

Spicy Corn and Bacon Macaroni and Cheese – spicy cheese sauce, roasted corn, bacon, and sauteed peppers and onion. Topped with bread crumbs. Delicious!

tex mex macaroni and cheese recipe

I’ll freely admit that this is not the most gorgeous food item to be featured on this blog, but what it lacks in beauty, it absolutely makes up for in flavor. I baked off two of the ramekins earlier in the day to photograph for the blog, and when they came out of the oven, they were perfect. Piled super high, perfectly brown, oozey cheese – I pulled them out of the oven and burnt myself and dropped them. And well, they weren’t so pretty after that. But I had to share this recipe with you, because you would be missing out if I didn’t.

I made this mac and cheese to go along with our Easter ham and it was by far my favorite thing on the table. Smoky corn and bacon, and just a little bit of heat from the pepper jack cheese and habanero. My kids ate it and enjoyed it, so that should tell you something. This is my new go-to mac and cheese recipe.

This recipe is not hard by any means, but if you are short on time, you can buy grilled corn in the frozen section. The original recipe calls for poblanos and chorizo, but since I am on a Sargento Flavor Journey, I thought that I would try using habanero pepper instead. I also had just gotten some Applegate bacon and decided to use that instead of chorizo. I like the crunch that the bacon added and I think that it might have been too spicy if I stuck with chorizo. I am thrilled with how this recipe turned out. I found tortilla crumbs at Whole Foods, but if you can’t find them, just finely crush some corn chips, or pulse them in the food processor.

Mac and cheese tip – for the best flavor, use a mixture of cheeses. I find that if I only use one kind, the flavor sometimes falls flat. I try to always use at least two kinds, but three or four work well too!

Ingredients

  • 2 ears corn on the cob, husks removed
  • 1 pound fusilli
  • 6 slices bacon, cut into 1/2 inch pieces
  • 1 onion, diced
  • 1 red pepper, diced
  • 1 habanero, seeded, deveined, and finely minced
  • 3 Tablespoons butter
  • 3 Tablespoons flour
  • 3 cups milk
  • 1 1/2 cups shredded Sargento Pepper Jack cheese
  • 1 1/2 cups shredded Sargento Extra Sharp Cheddar
  • 1 teaspoon salt
  • 1/4 teaspoon pepper
  • 3/4 cup crushed tortilla chips
  • 1/4 cup panko crumbs
  • 3 Tablespoons melted butter
  • 2 Tablespoons chopped cilantro
spicy corn and bacon macaroni and cheese recipe

How to Make Spicy Corn and Bacon Macaroni and Cheese

Step 1: Preheat the broiler and place the oven rack 5 1/2 inches from the heat. Line a baking sheet with aluminum foil and broil corn for 20 minutes, turning every 5 minutes. Let cool and cut kernels off of the cob.

oven roasted oven recipe

Step 2: Cook the pasta according to the package directions. Drain and set aside. Heat the bacon in a large sauté pan over medium-high heat. Cook until the bacon is crispy, drain on a paper towel-lined plate. Remove bacon grease, leaving 1 Tablespoon in pan. Add onion, pepper, and habanero.

spicy corn and bacon macaroni and cheese recipe

Step 3: Cook until soft and lightly browned. Add reserved corn. Set aside.

spicy corn and bacon macaroni and cheese recipe

Step 4: Mix tortilla crumbs, panko, melted butter, and cilantro.

spicy corn and bacon macaroni and cheese recipe

Step 5: Now you have all the pieces of this mac and cheese, it is time to move on to the cheese sauce.

spicy bacon and corn macaroni and cheese recipe

Step 6: In a medium saucepan, melt butter over medium heat. Whisk in flour and cook for 2 minutes or until golden brown.

how to make a roux

Step 7: Slowly whisk in milk and cook until thickened about 10 minutes. It will be thick enough when it coats the back of the spoon.

how to make bechamel sauce

Step 8: Remove from heat and add cheese.

spicy corn and bacon macaroni and cheese recipe

Step 9: Stir with a wooden spoon until smooth.

spicy corn and bacon macaroni and cheese recipe

Step 10: Add corn, onion, and pepper mixture, and reserved bacon. Pour sauce over pasta and toss to combine. Check for seasoning and add more salt and pepper as needed, I almost always have to add more. Pour into a 9×13 casserole dish that has been sprayed with cooking spray. Or individual ramekins (about 6).

spicy bacon and corn macaroni and cheese recipe

Step 11: Sprinkle with tortilla and panko mixture. Bake in a 400-degree oven for 12 to 15 minutes or until bubbly. Let stand 5 minutes before serving.

spicy corn and bacon macaroni and cheese recipe

Spicy Corn and Bacon Macaroni and Cheese

bakedbree
No ratings yet

Ingredients
  

  • 2 ears corn on the cob husks removed
  • 1 pound fusilli
  • 6 slices bacon cut into 1/2 inch pieces
  • 1 onion diced
  • 1 red pepper diced
  • 1 habanero seeded, deveined, and finely minced
  • 3 Tablespoons butter
  • 3 Tablespoons flour
  • 3 cups milk
  • 1 1/2 cups shredded Sargento Pepper Jack cheese
  • 1 1/2 cups shredded Sargento Sharp Cheddar
  • 1 teaspoon salt
  • 1/4 teaspoon pepper
  • 3/4 cup crushed tortilla chips
  • 1/4 cup panko crumbs
  • 3 Tablespoons melted butter
  • 2 Tablespoons chopped cilantro

Instructions
 

  • Preheat the broiler and place the oven rack 5 1/2 inches from the heat. Line a baking sheet with aluminum foil and broil corn for 20 minutes, turning every 5 minutes. Let cool and cut kernels off of the cob.
  • Cook the pasta according to the package directions. Drain and set aside. Heat the bacon in a large sauté pan over medium-high heat. Cook until the bacon is crispy, drain on a paper towel-lined plate. Remove bacon grease, leaving 1 Tablespoon in pan. Add onion, pepper, and habanero.
  • Cook until soft and lightly browned. Add reserved corn. Set aside.
  • Mix tortilla crumbs, panko, melted butter, and cilantro.
  • Now you have all the pieces of this mac and cheese, it is time to move on to the cheese sauce.
  • In a medium saucepan, melt butter over medium heat. Whisk in flour and cook for 2 minutes or until golden brown.
  • Slowly whisk in milk and cook until thickened about 10 minutes. It will be thick enough when it coats the back of the spoon.
  • Remove from heat and add cheese.
  • Stir with a wooden spoon until smooth.
  • Add corn, onion, and pepper mixture, and reserved bacon. Pour sauce over pasta and toss to combine. Check for seasoning and add more salt and pepper as needed, I almost always have to add more. Pour into a 9×13 casserole dish that has been sprayed with cooking spray. Or individual ramekins (about 6).
  • Sprinkle with tortilla and panko mixture. Bake in a 400-degree oven for 12 to 15 minutes or until bubbly. Let stand 5 minutes before serving.
Tried this recipe?Let us know how it was!

Leave a Comment

Your email address will not be published. Required fields are marked *

Recipe Rating